通过除塵阻火系統。然後進入換热器，再送到加热室，使气體达到燃燒反應温度，再通过催化床的作用，使有機廢气分解成二氧化碳和水，再進入換热器與低温气體進行热交換，使進入的气體温度升高达到反應温度。

如达不到反應温度，加热系統科通过自控系統實現補償加热。利用催化剂做中間體，使有機气體在較低的温度下，變成无害的水和二氧化碳气體。

産品性能特點：操作方便，設備工作时，實現自動控制，安全可靠。設備啟動，僅需15～30分鐘升温至起燃温度，能耗低。采用当今先進的貴.金.屬.钯、鉑浸漬的蜂窩狀陶瓷载體催化剂，比表面积大，阻力小，淨化率高。餘热可返回烘道，降低原烘道中消耗功率;也可作其它方面的热源。使用壽命长，催化剂一般两年更換，並且载體可再生。

First, through the dust removal and fire suppression system. Then it enters the heat exchanger and then sent to the heating chamber to make the gas reach the combustion reaction temperature. Then, through the action of the catalytic bed, the organic waste gas is decomposed into carbon dioxide and water, and then enters the heat exchanger for heat exchange with the low-temperature gas to raise the temperature of the incoming gas to the reaction temperature.

If the reaction temperature cannot be reached, the heating system department realizes compensated heating through the automatic control system. The catalyst is used as an intermediate to turn the organic gas into harmless water and carbon dioxide gas at a lower temperature.

Product performance features: convenient operation, automatic control when the equipment is working, safe and reliable. When the equipment is started, it only takes 15 ~ 30 minutes to raise the temperature to the ignition temperature, with low energy consumption. Adopt today's advanced expensive Kim Genus The honeycomb ceramic supported catalyst impregnated with palladium and platinum has large specific surface area, low resistance and high purification rate. The waste heat can be returned to the drying channel to reduce the power consumption in the original drying channel; It can also be used as a heat source in other aspects. The service life is long, the catalyst is generally replaced in two years, and the carrier is renewable.